Dry cleaning solvent (P-D-
680) used to clean parts is
Use
toxic and flammable.
ventilated
only in
well
protective
areas.
Wear
Do not
goggles and gloves.
smoke or allow open flames
or sparks in areas where
cleaning solvent is used or
Avoid contact with
stored.
eyes, skin, and clothing.
If contact is made, flush
with cold water and seek
If you
medical attention.
become dizzy while
using
cleaning solvent, get fresh
air immediately.
COMPRESSED AIR HAZARD
used
for
air
Compressed
cleaning purposes will not
Use only
exceed 30 PSI.
with effective chip guarding
protective
personal
and
(goggles/shield,
equipment
gloves, etc.)
Clean all plugs in SD-II.
Dry
thoroughly with compressed air.
Install drain plugs (36,37 and 38).
Remove filler cap (19) and filltrans-
mission with oil. Fill capacity is ap-
This also
proximately 24 gallons.
fills the differential and transfer
case.
Start engine and operate vehicle for
few minutes to fill
system.
a
Inspect for leaks.
Stop engine and check oil level on
dipstick (18). Add oil if necessary.
Card 23 Of 30
SEMI-ANNUALLY (Cent)
LO 5-3805-261-12
