TM-5-3805-263-14P-2 Grader Heavy Road Motorized Type I Nonsectionalized Type II Sectionalized Manual

ENGINE   DESIGN - TM-5-3805-263-14P-2_15
FUEL   SYSTEM - TM-5-3805-263-14P-2_16
FUEL INJECTION NOZZLE
FUEL   TRANSFER   PUMP
GOVERNOR - TM-5-3805-263-14P-2_19
Governor    Servo
FUEL   SYSTEM - TM-5-3805-263-14P-2_21
A I R   I N L E T   A N D   E X H A U S T   S Y S T E M
AIR INLET AND EXHAUST SYSTEM
CYLINDER HEAD AND VALVES
LUBRICATION   SYSTEM - TM-5-3805-263-14P-2_25
OIL FLOW THROUGH THE OIL FILTER AND OIL COOLER
ROCKER ARM OIL SUPPLY
COOLING   SYSTEM
COOLANT FOR AIR COMPRESSOR
BASIC   BLOCK - TM-5-3805-263-14P-2_30
ELECTRICAL   SYSTEM - TM-5-3805-263-14P-2_31
STARTING   SYSTEM   COMPONENTS
OTHER   COMPONENTS
ELECTRICAL SYSTEM SCHEMATIC
TROUBLESHOOTING - TM-5-3805-263-14P-2_35
ENGINE CRANKSHAFT WILL NOT TURN WHEN START SWITCH IS ON
MISFIRING OR RUNNING ROUGH
SUDDEN CHANGES IN ENGINE SPEED (rpm)
LOUD COMBUSTION NOISE (KNOCK)
OIL IN COOLING SYSTEM
LITTLE MOVEMENT OF ROCKER ARM AND TOO MUCH VALVE CLEARANCE
LITTLE OR NO VALVE CLEARANCE
TOO MUCH WHITE OR BLUE SMOKE
ENGINE USES TOO MUCH LUBRICATION OIL
STARTER MOTOR DOES NOT TURN
ALTERNATOR HAS NOISE
FUEL   SYSTEM - TM-5-3805-263-14P-2_47
TESTING 8N7005 FUEL INJECTION NOZZLES
FUEL SYSTEM
Flush the Nozzle
Orifice Restriction Test
FUEL   INJECTION   LINES - TM-5-3805-263-14P-2_52
FUEL   SYSTEM - TM-5-3805-263-14P-2_53
FUEL   SYSTEM CONT.
FUEL SYSTEM CONT. - TM-5-3805-263-14P-2_55
FUEL SYSTEM CONT. - TM-5-3805-263-14P-2_56
FUEL SYSTEM CONT. - TM-5-3805-263-14P-2_57
FUEL SYSTEM CONT. - TM-5-3805-263-14P-2_58
FUEL SYSTEM CONT. - TM-5-3805-263-14P-2_59
FUEL SYSTEM CONT. - TM-5-3805-263-14P-2_60
FUEL SYSTEM CONT. - TM-5-3805-263-14P-2_61
FUEL SYSTEM CONT. - TM-5-3805-263-14P-2_62
FUEL SYSTEM CONT. - TM-5-3805-263-14P-2_63
FUEL SETTING INFORMATION
GOVERNOR   ADJUSTMENTS
Checking Balance Point
AIR   INLET   AND   EXHAUST   SYSTEM
TURBOCHARGER - TM-5-3805-263-14P-2_68
COMPRESSION
VALVE    CLEARANCE
PROCEDURE FOR MEASURING CAMSHAFT LOBES
LUBRICATION   SYSTEM - TM-5-3805-263-14P-2_72
Crankcase   Oil   Level
C O O L I N G   S Y S T E M
COOLING    SYSTEM
Checking Fan Speed
Pressure Cap
Filler Cap and Pressure Relief Valve
Water   Temperature   Regulator
BASIC   BLOCK - TM-5-3805-263-14P-2_80
CYLINDER   BLOCK - TM-5-3805-263-14P-2_81
CYLINDER   BLOCK CONT.
Bore Runout (radial eccentricity) of the Flywheel
OIL PUMP INSTALLATION
ELECTRICAL   SYSTEM - TM-5-3805-263-14P-2_85
Alternator Regulator (Delco-Remy)
Delco-Remy   Alternator;   Pulley   Nut   Tightening
Delco-Remy Alternator; Pulley Nut Tightening CONT.
P i n i o n    C l e a r a n c e    A d j u s t m e n t    ( D e l c o - R e m y )
CHAPTER 2 ENGINE DISASSEMBLY   AND   ASSEMBLY
B A T T E R I E S
MUFFLER
HOOD
ELECTRIC STARTING MOTOR
ALTERNATOR - TM-5-3805-263-14P-2_96
ALTERNATOR - TM-5-3805-263-14P-2_97
AIR COMPRESSOR GOVERNOR
AIR COMPRESSOR\
TURBOCHARGER - TM-5-3805-263-14P-2_100
TURBOCHARGER CONT. - TM-5-3805-263-14P-2_101
TURBOCHARGER CONT. - TM-5-3805-263-14P-2_102
TURBOCHARGER CONT. - TM-5-3805-263-14P-2_103
TURBOCHARGER CONT. - TM-5-3805-263-14P-2_104
TURBOCHARGER CONT. - TM-5-3805-263-14P-2_105
TURBOCHARGER CONT. - TM-5-3805-263-14P-2_106
TURBOCHARGER CONT. - TM-5-3805-263-14P-2_107
TURBOCHARGER CONT. - TM-5-3805-263-14P-2_108
ENGINE   FRONT   SUPPORT
AIR   CLEANER   HOUSING CONT.
WATER TEMPERATURE REGULATOR
WATER   PUMP
WATER   PUMP CONT.
WATER PUMP CONT. - TM-5-3805-263-14P-2_114
WATER PUMP CONT. - TM-5-3805-263-14P-2_115
WATER PUMP CONT. - TM-5-3805-263-14P-2_116
WATER PUMP CONT. - TM-5-3805-263-14P-2_117
WATER PUMP CONT. - TM-5-3805-263-14P-2_118
WATER   PUMP,   MAIN   FRAME   LOCKPIN
FAN   DRIVE   AND   SUPPORT
FAN   DRIVE   AND   SUPPORT CONT.
FAN   DRIVE
FAN   DRIVE CONT.
FAN DRIVE CONT.
RADIATOR   AND   GUARD - TM-5-3805-263-14P-2_125
RADIATOR   AND   GUARD - TM-5-3805-263-14P-2_126
RADIATOR   AND   GUARD CONT.
RADIATOR AND GUARD CONT.
RADIATOR   CORE   AND   HYDRAULIC   OIL   COOLER
RADIATOR   CORE   AND   HYDRAULIC   OIL   COOLER CONT.
RADIATOR CORE AND HYDRAULIC OIL COOLER CONT.
OIL   FILTER   BASE
OIL FILTER BASE
TRANSMISSION   OIL   COOLER
TRANSMISSION   OIL   COOLER CONT.
ENGINE   OIL   COOLER
FUEL   PRIMING   AND   PRIMARY   FILTER   PUMP   GROUP
FUEL   PRIMING   AND   PRIMARY   FILTER   PUMP   GROUP CONT.
FUEL   FILTER   BASE   AND   FILTER
FUEL   INJECTION   LINES - TM-5-3805-263-14P-2_140
FUEL   INJECTION   NOZZLES
FUEL   INJECTION   PUMP   HOUSING   AND   GOVERNOR
FUEL   INJECTION   PUMP   HOUSING   AND   GOVERNOR CONT.
FUEL INJECTION PUMP HOUSING AND GOVERNOR CONT. - TM-5-3805-263-14P-2_144
FUEL INJECTION PUMP HOUSING AND GOVERNOR CONT. - TM-5-3805-263-14P-2_145
FUEL INJECTION PUMP HOUSING AND GOVERNOR CONT. - TM-5-3805-263-14P-2_146
FUEL INJECTION PUMP HOUSING AND GOVERNOR CONT. - TM-5-3805-263-14P-2_147
FUEL   INJECTION   PUMP   HOUSING
FUEL   INJECTION   PUMP   HOUSING CONT.
FUEL INJECTION PUMP HOUSING CONT. CONT.
FUEL INJECTION PUMP HOUSING CONT. CONT. - TM-5-3805-263-14P-2_151
FUEL INJECTION PUMP HOUSING CONT. CONT. - TM-5-3805-263-14P-2_152
FUEL INJECTION PUMP HOUSING CONT. CONT. - TM-5-3805-263-14P-2_153
FUEL INJECTION PUMP HOUSING CONT. CONT. - TM-5-3805-263-14P-2_154
FUEL INJECTION PUMP HOUSING CONT. CONT. - TM-5-3805-263-14P-2_155
GOVERNOR - TM-5-3805-263-14P-2_156
GOVERNOR CONT. - TM-5-3805-263-14P-2_157
GOVERNOR CONT. - TM-5-3805-263-14P-2_158
GOVERNOR CONT. - TM-5-3805-263-14P-2_159
GOVERNOR CONT. - TM-5-3805-263-14P-2_160
GOVERNOR CONT. - TM-5-3805-263-14P-2_161
GOVERNOR CONT. - TM-5-3805-263-14P-2_162
GOVERNOR CONT. - TM-5-3805-263-14P-2_163
GOVERNOR CONT. - TM-5-3805-263-14P-2_164
GOVERNOR CONT. - TM-5-3805-263-14P-2_165
GOVERNOR CONT. - TM-5-3805-263-14P-2_166
GOVERNOR CONT. - TM-5-3805-263-14P-2_167
GOVERNOR CONT. - TM-5-3805-263-14P-2_168
GOVERNOR CONT. - TM-5-3805-263-14P-2_169
GOVERNOR CONT. - TM-5-3805-263-14P-2_170
FUEL TRANSFER PUMP
FUEL TRANSFER PUMP CONT.
FUEL TRANSFER PUMP CONT. - TM-5-3805-263-14P-2_173
FUEL TRANSFER PUMP CONT. - TM-5-3805-263-14P-2_174
FUEL TRANSFER PUMP CONT. - TM-5-3805-263-14P-2_175
VALVE COVER
ROCKER SHAFT AND PUSH RODS
ROCKER SHAFT
ROCKER SHAFT CONT.
EXHAUST MANIFOLD
CYLINDER   HEAD
CYLINDER   HEAD CONT.
CYLINDER HEAD CONT. - TM-5-3805-263-14P-2_183
CYLINDER HEAD CONT. - TM-5-3805-263-14P-2_184
CYLINDER HEAD CONT. - TM-5-3805-263-14P-2_185
CYLINDER HEAD CONT. - TM-5-3805-263-14P-2_186
VALVE LIFTERS
SPACER   PLATE
PUMP GROUP DRIVE SHAFT
CRANKSHAFT HUB
CRANKSHAFT FRONT SEAL AND WEAR SLEEVE
ENGINE - TM-5-3805-263-14P-2_192
ENGINE CONT. - TM-5-3805-263-14P-2_193
ENGINE CONT. - TM-5-3805-263-14P-2_194
ENGINE CONT. - TM-5-3805-263-14P-2_195
ENGINE CONT. - TM-5-3805-263-14P-2_196
ENGINE CONT. - TM-5-3805-263-14P-2_197
TIMING GEAR COVER
TIMING GEAR COVER CONT.
TIMING GEARS
TIMING GEARS AND PLATE
TIMING GEARS AND PLATE CONT. - TM-5-3805-263-14P-2_202
TIMING GEARS AND PLATE CONT. - TM-5-3805-263-14P-2_203
CAMSHAFT
CAMSHAFT CONT.
CAMSHAFT   BEARINGS
OIL PAN
OIL PAN PLATE
OIL PUMP
DISASSEMBLE OIL PUMP
OIL PUMP - TM-5-3805-263-14P-2_211
OIL PUMP CONT.
OIL PUMP - TM-5-3805-263-14P-2_213
CONNECTING ROD BEARINGS
CRANKSHAFT MAIN BEARINGS
CRANKSHAFT MAIN BEARINGS CONT.
PISTONS
PISTONS CONT. - TM-5-3805-263-14P-2_218
PISTONS CONT. - TM-5-3805-263-14P-2_219
PISTONS CONT. - TM-5-3805-263-14P-2_220
CYLINDER   LINERS
CYLINDER   LINERS CONT.
FLYWHEEL - TM-5-3805-263-14P-2_223
FLYWHEEL HOUSING
CRANKSHAFT REAR SEAL AND WEAR SLEEVE
CRANKSHAFT AND GEAR
CRANKSHAFT AND GEAR CONT.
BALANCER   SHAFTS
BALANCER SHAFT BEARINGS
PISTON COOLING ORIFICES
CHAPTER 3 ENGINE SPECIFICATIONS
ENGINE   DESIGN - TM-5-3805-263-14P-2_233
TACHOMETER   DRIVE   GROUP
GOVERNOR CONTROL GROUP
FRONT   TIMING   GEAR   GROUP
GOVERNOR   GROUP
FUEL INJECTION PUMP GROUP
INJECTION NOZZLE
CAMSHAFT   GROUP
VALVES
CYLINDER HEAD
EXHAUST MANIFOLD GROUP
TURBOCHARGER GROUP
OIL PUMP GROUP
ENGINE OIL PRESSURE
OIL BREATHER CAP
RADIATOR GROUP
CYLINDER   BLOCK - TM-5-3805-263-14P-2_249
CYLINDER LINER PROJECTION
PISTONS AND RINGS
CONNECTING ROD ASSEMBLY
CRANKSHAFT GROUP
BEARING SURFACE (JOURNAL) FOR MAIN BEARINGS
BEARING SURFACE (JOURNAL) FOR   CONNECTING   RODS
MAIN BEARINGS AND CONNECTING ROD BEARINGS
FAN DRIVE GROUP
FLYWHEEL - TM-5-3805-263-14P-2_258
FLYWHEEL   HOUSING
FLYWHEEL HOUSING BORE
CHARGING   ALTERNATOR   GROUP
ELECTRIC   STARTING   MOTOR   GROUP
MAGNETIC SWITCH GROUP
SOLENOID ASSEMBLY
AIR PRESSURE INDICATOR
WATER TEMPERATURE INDICATOR
PART TWO POWER TRAIN
CHAPTER 1 POWER   TRAIN SYSTEMS OPERATION TESTING AND ADJUSTING
POWER FLOW
T R A N S M I S S I O N   G E A R S
PLANETARY   TRANSMISSION - TM-5-3805-263-14P-2_271
POWER FLOW IN FIRST SPEED, NO. 5 AND NO. 6 CLUTCHES ENGAGED
PLANETARY   TRANSMISSION - TM-5-3805-263-14P-2_273
PLANETARY TRANSMISSION
PLANETARY TRANSMISSION CONT.
PLANETARY TRANSMISSION CONT. - TM-5-3805-263-14P-2_276
PLANETARY TRANSMISSION CONT. - TM-5-3805-263-14P-2_277
TRANSMISSION   LUBRICATION   SYSTEM - TM-5-3805-263-14P-2_278
TRANSMISSION   LUBRICATION   SYSTEM - TM-5-3805-263-14P-2_279
TRANSMISSION   LUBRICATION   SYSTEM - TM-5-3805-263-14P-2_280
TRANSMISSION HYDRAULIC CONTROLS
TRANSMISSION    VALVES
NEUTRAL WITH ENGINE OFF - TM-5-3805-263-14P-2_283
NEUTRAL WITH ENGINE OFF - TM-5-3805-263-14P-2_284
NEUTRAL WITH ENGINE RUNNING - TM-5-3805-263-14P-2_285
NEUTRAL WITH ENGINE RUNNING - TM-5-3805-263-14P-2_286
FIRST SPEED FORWARD - TM-5-3805-263-14P-2_287
FIRST SPEED FORWARD - TM-5-3805-263-14P-2_288
FIFTH   SPEED   REVERSE - TM-5-3805-263-14P-2_289
FIFTH   SPEED   REVERSE - TM-5-3805-263-14P-2_290
PILOT SELECTOR VALVE
TRANSMISSION   HYDRAULIC   CONTROLS
DIFFERENTIAL AND BEVEL GEAR
DIFFERENTIAL AND BEVEL GEAR
FINAL AND TANDEM DRIVES
TROUBLE SHOOTING
CLUTCHES    ENGAGED IN   TRANSMISSION
CHAPTER 2 POWER TRAIN POWER SHIFT TRANSMISSION TESTING AND ADJUSTING
POWER SHIFT TRANSMISSION TESTING AND ADJUSTING
LOCATION OF THE PRESSURE TAPS
GOVERNOR CONTROL LEVER
POWER SHIFT TRANSMISSION TESTING AND ADJUSTING - TM-5-3805-263-14P-2_302
SPEED   AND   DIRECTION   CABLE   CONTROLS
POWER SHIFT TRANSMISSION TESTING AND ADJUSTING - TM-5-3805-263-14P-2_304
CABLE FOR MANUAL MODULATION VALVE
CHAPTER   3 POWER   TRAIN DISASSEMBLY   AND   ASSEMBLY
AXLES
AXLES CONT.
REAR WHEELS
DRIVE CHAINS
DRIVE   CHAINS
FINAL DRIVES, BRAKE & WHEEL SPINDLE HOUSINGS
BRAKE AND WHEEL SPINDLE HOUSINGS - TM-5-3805-263-14P-2_313
BRAKE AND WHEEL SPINDLE HOUSINGS CONT. - TM-5-3805-263-14P-2_314
BRAKE AND WHEEL SPINDLE HOUSINGS - TM-5-3805-263-14P-2_315
BRAKE AND WHEEL SPINDLE HOUSINGS CONT. - TM-5-3805-263-14P-2_316
BRAKE AND WHEEL SPINDLE HOUSINGS CONT. - TM-5-3805-263-14P-2_317
BRAKE AND WHEEL SPINDLE HOUSINGS CONT. - TM-5-3805-263-14P-2_318
TANDEM HOUSINGS
DRIVE SPROCKETS
FINAL DRIVES - TM-5-3805-263-14P-2_321
FINAL DRIVES - TM-5-3805-263-14P-2_322
FINAL DRIVES - TM-5-3805-263-14P-2_323
FINAL DRIVES CONT.
FINAL DRIVES CONT. - TM-5-3805-263-14P-2_325
FINAL DRIVES CONT. - TM-5-3805-263-14P-2_326
FINAL DRIVES CONT. - TM-5-3805-263-14P-2_327
TRANSMISSION OIL FILTER BASE, RELIEF CONTROL VALVE
TRANSMISSION OIL FILTER BASE
RELIEF CONTROL VALVE - TM-5-3805-263-14P-2_330
RELIEF CONTROL VALVE - TM-5-3805-263-14P-2_331
RELIEF CONTROL VALVE CONT.
TRANSMISSION OIL AND SCAVENGE PUMP
TRANSMISSION OIL AND SCAVENGE PUMP CONT.
TRANSMISSION OIL AND SCAVENGE PUMP CONT. - TM-5-3805-263-14P-2_335
TRANSMISSION OIL AND SCAVENGE PUMP CONT. - TM-5-3805-263-14P-2_336
TRANSMISSION OIL AND SCAVENGE PUMP CONT. - TM-5-3805-263-14P-2_337
TRANSMISSION OIL AND SCAVENGE PUMP CONT. - TM-5-3805-263-14P-2_338
DIFFERENTIAL
DIFFERENTIAL CONT. - TM-5-3805-263-14P-2_340
DIFFERENTIAL CONT. - TM-5-3805-263-14P-2_341
DIFFERENTIAL CONT. - TM-5-3805-263-14P-2_342
DIFFERENTIAL CONT. - TM-5-3805-263-14P-2_343
DIFFERENTIAL CONT. - TM-5-3805-263-14P-2_344
DIFFERENTIAL CONT. - TM-5-3805-263-14P-2_345
DIFFERENTIAL CONT. - TM-5-3805-263-14P-2_346
DIFFERENTIAL CONT. - TM-5-3805-263-14P-2_347
DIFFERENTIAL CONT. - TM-5-3805-263-14P-2_348
DIFFERENTIAL CONT. - TM-5-3805-263-14P-2_349
DIFFERENTIAL CONT. - TM-5-3805-263-14P-2_350
DIFFERENTIAL CONT. - TM-5-3805-263-14P-2_351
TRANSMISSION - TM-5-3805-263-14P-2_352
TRANSMISSION CONT. - TM-5-3805-263-14P-2_353
TRANSMISSION CONT. - TM-5-3805-263-14P-2_354
TRANSMISSION CONT. - TM-5-3805-263-14P-2_355
TRANSMISSION CONT. - TM-5-3805-263-14P-2_356
TRANSMISSION CONT. - TM-5-3805-263-14P-2_357
TRANSMISSION CONT. - TM-5-3805-263-14P-2_358
TRANSMISSION CONT. - TM-5-3805-263-14P-2_359
TRANSMISSION CONT. - TM-5-3805-263-14P-2_360
TRANSMISSION CONT. - TM-5-3805-263-14P-2_361
TRANSMISSION CONT. - TM-5-3805-263-14P-2_362
TRANSMISSION CONT. - TM-5-3805-263-14P-2_363
TRANSMISSION CONT. - TM-5-3805-263-14P-2_364
TRANSMISSION CONT. - TM-5-3805-263-14P-2_365
TRANSMISSION CONT. - TM-5-3805-263-14P-2_366
TRANSMISSION CONT. - TM-5-3805-263-14P-2_367
TRANSMISSION CONT. - TM-5-3805-263-14P-2_368
TRANSMISSION CONT. - TM-5-3805-263-14P-2_369
TRANSMISSION CONT. - TM-5-3805-263-14P-2_370
TRANSMISSION CONT. - TM-5-3805-263-14P-2_371
TRANSMISSION GEARS
TRANSMISSION GEARS CONT.
TRANSMISSION GEARS CONT. - TM-5-3805-263-14P-2_374
TRANSMISSION GEARS CONT. - TM-5-3805-263-14P-2_375
TRANSMISSION GEARS CONT. - TM-5-3805-263-14P-2_376
TRANSMISSION GEARS CONT. - TM-5-3805-263-14P-2_377
TRANSMISSION GEARS CONT. - TM-5-3805-263-14P-2_378
TRANSMISSION GEARS CONT. - TM-5-3805-263-14P-2_379
TRANSMISSION GEARS CONT. - TM-5-3805-263-14P-2_380
TRANSMISSION GEARS CONT. - TM-5-3805-263-14P-2_381
TRANSMISSION GEARS CONT. - TM-5-3805-263-14P-2_382
TRANSMISSION HYDRAULIC CONTROL VALVES
TRANSMISSION HYDRAULIC CONTROL VALVES CONT.
TRANSMISSION HYDRAULIC CONTROL VALVES CONT. - TM-5-3805-263-14P-2_385
TRANSMISSION HYDRAULIC CONTROL VALVES CONT. - TM-5-3805-263-14P-2_386
TRANSMISSION HYDRAULIC CONTROL VALVES CONT. - TM-5-3805-263-14P-2_387
TRANSMISSION HYDRAULIC CONTROL VALVES CONT. - TM-5-3805-263-14P-2_388
TRANSMISSION HYDRAULIC CONTROL VALVES CONT. - TM-5-3805-263-14P-2_389
CHAPTER 4 POWER TRAIN SPECIFICATIONS
TRANSMISSION     GEARS
TRANSMISSION - TM-5-3805-263-14P-2_392
TRANSMlSSlON OIL PUMP
TRANSMISSION CONTROL VALVE GROUP
TRANSMISSION VALVE GROUP (4 UNIT) CONTROL VALVES
TRANSMISSION VALVE GROUP (DIFFERENTIAL) SELECTOR AND PRESSURE CONTROL
TRANSMISSION VALVE GROUP (MODULATING)
TRANSMISSION CONTROL
GEAR   GROUP 2G6010 DIFFERENTIAL AND BEVEL
ADJUSTMENT PROCEDURE FOR BACKLASH OF RING GEAR AND PRELOAD OF DIFFERENTIAL SUPPORT BEARINGS THROUGH THE SIDE BORES IN THE DIFFERENTIAL   CASE
FINAL DRIVE
WHEEL SPINDLE
WHEEL   GROUP
FRAME AND CASE GROUP

Western Governors University

Privacy Statement
Press Release
Contact

Integrated Publishing, Inc. - A (SDVOSB) Service Disabled Veteran Owned Small Business